- Research article
- Open Access
Effect of challenge of pigs previously immunised with inactivated vaccines containing homologous and heterologous Mycoplasma hyopneumoniae strains
© Villarreal et al; licensee BioMed Central Ltd. 2012
Received: 4 July 2011
Accepted: 6 January 2012
Published: 6 January 2012
Mycoplasma hyopneumoniae is the primary cause of enzootic pneumonia in pigs. Although vaccination is an important control tool, the results observed under field conditions are variable. This may be due to antigenic differences between the strains circulating in pig herds and the vaccine strain. This study compared the protective efficacy of four bacterins against challenge infection with a highly virulent field strain of M. hyopneumoniae.
Seventy eight, one-week old piglets were randomly assigned to five treatment groups (A, B, C, D, E), 14 piglets each, and a negative control group (F) consisting of 8 piglets. All pigs were injected at 1 (D7) and 4 weeks of age (D28), with 2 ml of either a placebo or a bacterin based on selected M. hyopneumoniae strains, namely A (F7.2C), B (F20.1L), C (B2V1W20 1A-F), D (J strain), E (placebo; positive control), F (placebo; negative control). At D56, all pigs except those of group F were challenged intratracheally with 7 ml culture medium containing 107 CCU/ml of M. hyopneumoniae strain F7.2C. All pigs were euthanized and necropsied at D84. The severity of coughing and pneumonia lesions were the main parameters. Immunofluorescence (IF) testing, nested PCR testing of bronchoalveolar lavage (BAL) fluid and serology for M. hyopneumoniae were also performed.
The different bacterins only slightly improved clinical symptoms (average 0.38 in vaccinated groups vs. 0.45 in group E) and histopathological lung lesions (average 3.20 in vaccinated groups vs. 3.45 in group E), but did not improve macroscopic lung lesions (score 4.30 vs. 4.03 in group E). None of the vaccines was significantly and/or consistently better or worse than the other ones. All bacterins evoked a serological response in the vaccinated animals. All pigs, except those from group F, were positive with nPCR in BAL fluid at D84.
The bacterins did not induce a clear overall protection against challenge infection, and there were no significant differences in protective efficacy between bacterins containing homologous and heterologous M. hyopneumoniae strains. Further research is necessary to better characterize the antigens involved in protection and to elucidate the protective immunity responses following M. hyopneumoniae vaccination and/or infection.
Mycoplasma hyopneumoniae is the primary cause of enzootic pneumonia in pigs, a disease causing major economic losses to the pig industry worldwide due to reduced performance and increased medication [1, 2]. Control of enzootic pneumonia can be accomplished by optimizing herd management practices and housing conditions, and by using antimicrobial medication and/or vaccination [2–4].
Vaccination with the commercially available vaccines is frequently practiced worldwide. Most vaccines are adjuvanted bacterins, and they generally provide good results in terms of improving clinical symptoms and lung lesions, and in decreasing performance losses and antimicrobial medication due to M. hyopneumoniae infections. However, the effects of vaccination may vary from herd to herd , and also under experimental conditions, it has been shown that the effects of vaccination differ depending on the challenge strain used to inoculate the animals . The variable results observed under field conditions may be due, among other factors, to antigenic differences between the strains circulating in pig herds and the vaccine strain. Previous studies have demonstrated that M. hyopneumoniae strains circulating in pig herds display considerable variation at genomic  and protein level , and also in terms of virulence, major differences between strains have been demonstrated [8, 9]. The current commercial vaccines used to control enzootic pneumonia are mostly based on the J-strain, which was originally isolated from a pig herd in the UK (Goodwin and Whittlestone, 1963). It can therefore be questioned whether this strain has similar characteristics as the M. hyopneumoniae strains circulating in pig herds in other parts of the world [6, 10].
The aim of this study was to compare the protective efficacy of four bacterins against challenge infection with a highly virulent field strain of M. hyopneumoniae. One of the bacterins was based on the challenge strain, two were based on other M. hyopneumoniae field strains and one contained the J strain.
Animals and experimental design
Seventy eight cross-bred pigs from a herd free of M. hyopneumoniae were included in the study. The herd was free from M. hyopneumoniae for more than 10 years based on regular monitoring of clinical symptoms, pneumonia lesions at slaughter, and serological testing for presence of antibodies against M. hyopneumoniae. The piglets were weaned at one week of age, and transported to the experimental facilities. They were randomly allocated to five different treatment groups (A, B, C, D, E) of 14 piglets each, and a negative control group (F) of 8 piglets. Every group was housed in a different room and each room had an own ventilation system to avoid transmission of infection from one group to another.
Pigs were vaccinated twice intramuscularly with 2 ml of either a placebo consisting of phosphate buffered saline solution (groups E and F) or a bacterin (groups A-D). The first time, they were vaccinated one day after transport to the experimental facilities (D7) and again three weeks later (D28). Vaccines A, B and C were based on field strains: A on F7.2C, B on F20.1L, and C on B2V1W20 1A-F. Previous studies revealed that these strains are genetically and antigenically different [7, 11]. Vaccine D was based on the J strain (Mypravac suis®, laboratorios HIPRA).
Different groups and experimental design.
Number of pigs
Strain used in bacterin
Challenge infection at D56
Necropsy at D84
The study was conducted after approval of the ethical committee for conducting animal experiments within CEYC (approval number EID-2009-031).
Preparation of the bacterins
The selected M. hyopneumoniae strains for producing bacterins A, B and C, together with the J strain, were cultured during three weeks in modified Friis' medium  at 37°C in an atmosphere containing 5% CO2. The Mycoplasmas were inactivated with binary ethylamine to obtain a whole-cell bacterin in an aqueous adjuvant suspension. All bacterins were adjusted to the same M. hyopneumoniae cell concentration namely 7.7 log10 CCU/ml, before inactivation.
Parameters of comparison and sampling of pigs
After intratracheal inoculation and until the end of the study, piglets were observed daily for a minimum of 15 minutes. The severity of coughing was assessed using a respiratory disease score (RDS) as described by Halbur et al. . Body condition, appetite, presence of dyspnea and tachypnea were also recorded. The RDS could range from 0 to 6: 0 (no coughing), 1 (mild coughing after an encouraged move), 2 (mild coughing in rest), 3 (moderate coughing after encouraged move), 4 (moderate coughing in rest), 5 (severe coughing after encouraged move), 6 (severe coughing in rest). The daily RDS values were summed and averaged on D84.
Macroscopic lung lesions, histopathology and immunofluorescence (IF) testing for M. hyopneumoniae
After necropsy, the lungs were removed to score the macroscopic pneumonia lesions according to Hannan et al. , with values ranging from 0 (no lesions) to 35 (entire lung affected). Samples from the right apical, cardial and diaphragmatic lung lobe of each pig were collected for histopathological examination and IF testing. If lung lesions were present, tissue samples for IF testing were collected from the edge of a lesion.
For histopathological examination, the lung tissue samples were fixed in 10% neutral formalin, processed and embedded in paraffin. After hematoxylin and eosin staining, samples were scored using light microscopy. Scores could range from 0 to 5, according to the degree of peribronchiolar and perivascular lymphohistiocytic infiltration, as well as cuffing formation [15, 16]. Scores 1 (limited cellular infiltrates- macrophages and lymphocyte- around bronchioles; with airways and alveolar spaces free of cellular exudates) and 2 (moderate infiltrates with mild diffuse cellular exudates into airways) were classified as lesions not related to Mycoplasma infections. Scores 3, 4, 5 were considered to be associated with Mycoplasma infection (mild, moderate or severe- broncho-interstitial (cuffing) pneumonia, surrounding bronchioles but extending to the interstitium, with lymphofollicular infiltration and mixed inflammatory cell exudates). The average histopathological lung score per group was calculated.
A direct IF assay  was performed to assess the load of M. hyopneumoniae organisms in a semi-quantitative way. The scores could range ranged from 0 to 3: 0 (no IF), 1 (limited IF), 2 (moderate IF), and 3 (intense IF) .
Nasal swabs, bronchoalveolar lavage fluid, and nPCR
Nasal swabs were collected from all animals at D7, D28, D56, D70 and just before euthanasia on D84. At necropsy on D84, 20 ml of PBS were slowly infused in the left lung and aspirated back into the syringe. The recovered bronchoalveolar lavage (BAL) fluid was aliquoted, immediately cooled at 4°C, and subsequently stored at -70°C until analysis.
DNA was extracted from the nasal swabs and BAL fluid with the QIAGEN protocol for purification of total DNA from animal blood and tissues (QIAGEN, DNeasy Blood & Tissue Kit, Belgium). For detection of M. hyopneumoniae DNA, a nPCR-test based on a modified protocol described by Stärk et al.  was performed . ].
Blood samples were taken from all pigs at D7, D28, D56, D70 and D84 and tested for the presence of antibodies against M. hyopneumoniae using the DAKO® Mhyo ELISA (Oxoid Limited, Hampshire, UK). Sera with inhibition percentage (IP) > 50% were considered positive, IP values < 50% were considered negative. Intermediate IP values were considered doubtful and classified as negative for the data analysis.
DWG and FCR
Pigs were individually weighed on D7, D28, D56, D70 and D84. The daily weight gain (DWG) and feed conversion ratio (FCR) were calculated for all groups. The DWG (g/day) for different periods during the study was estimated from the difference between the starting and final weight at a period, divided by the number of days lived by the pigs during that period. The FCR was calculated as the amount of feed consumed divided by the mean increase in live weight during each period.
A sample of BAL fluid per pig in each group was inoculated on Columbia agar supplemented with 5% sheep blood (Oxoid, Hampshire, UK) with a Staphylococcus pseudintermedius streak for support of Actinobacillus and Haemophilus sp. growth, and on Columbia CNA agar with 5% sheep blood (Oxoid, Hampshire, UK). As described by Quinn et al. , plates were incubated in a 5% CO2-enriched environment at 37°C for 48 h for identification of respiratory bacteria in the lungs.
The RDS scores, macroscopic, histopathological lung lesions, IF scores, serology (IP values) and DWG in the different groups were statistically analyzed using one-way analysis of variance (ANOVA). For each parameter, pair-wise comparisons between groups were obtained using Bonferroni's test. The proportion of serologically positive pigs, and pigs positive by nested PCR on nasal swabs and BALF at different time points (D7, D28, D56, D70 and D84) were analyzed using logistic regression. Group F was excluded from the statistical analysis as this group only served as a sentinel group.
Statistical results were considered significant when P ≤ 0.05 (two-sided test). The statistical package SPSS 17.0 for Windows (SPSS 17.0, SPSS Inc., IL, USA) was used for the analysis.
Results (mean ± SD) of the different parameters.
0.29 ± 0.09a,b,c
0.50 ± 0.21a,b
0.53 ± 0.25a,b
0.18 ± 0.14,a,c
0.61 ± 0.32b
0.00 ± 0.00c
Macroscopic lung lesions
6.86 ± 4.54a
2.59 ± 1.39b,c
3.33 ± 0.97b,c
4.59 ± 2.82a,b,c
4.06 ± 2.45a,b
0.23 ± 0.35c
Histopathological lung lesions
3.49 ± 0.67a
3.48 ± 0.65a
2.89 ± 0.74a
2.93 ± 0.76a
3.45 ± 0.73a
1.29 ± 0.30a
1.63 ± 0.97a,b
0.91 ± 0.86a,c
1.27 ± 0.21a,b,c
1.77 ± 0.70a,b
2.23 ± 1.05b
0.14 ± 0.38c
Macroscopic, histopathological lung lesions and IF testing for M. hyopneumoniae
The macroscopic lung lesion scores in groups A, B, C, D, E and F were 6.86, 2.59, 3.33, 4.59, 4.06 and 0.23, respectively. Only two pigs had very mild lung lesions in group F. Group A had significantly higher scores than group B and C (P < 0.05). There were no significant differences between groups B, C, D and E (Table 1).
The scores for the histopathological lung lesions in groups A, B, C, D, and E were 3.49, 3.48, 2.89, 2.93 and 3.45, respectively (P > 0.05) (Table 1). The pigs in group F did not show Mycoplasma-like histopathological lesions. The average score (1.29) in group F was significantly lower than the scores of the other groups (P < 0.05).
All pigs, except for those in group F, were positive for IF staining. The highest IF score was recorded in group E (2.23), the lowest in group B (0.91) (P < 0.01). The scores in groups A, C and D were 1.63, 1.27 and 1.77, respectively (P > 0.05). One pig from group F had a positive IF testing in one of the 3 sampled lobes.
nPCR testing on nasal swabs and BAL fluid
Number (%) of positive pigs by nested PCR.
Age of pigs
Percentage of seropositive pigs and inhibition percentage (IP) in each group.
Age of pigs
No relevant bacterial growth was observed at 2, 4, nor 7 days after plating the BALF samples on Columbia blood agar and CNA plates.
Daily weight gain (DWG) (g/day) (mean ± SD) and feed conversion rate (FCR) for each group (A-F).
The number of pigs that died in the different groups were 4, 3, 9, 4, 4 and 1 in groups A, B, C, D, E and F, respectively. The majority of them died during the pre-challenge phase due to E. coli diarrhea. One animal died during anesthesia, and in two other animals (group C), a non-serotypable Streptococcus suis strain was isolated from the lung and from the lung and liver, respectively. Clinically diseased pigs were medicated per os (1 ml/piglet) with a combination of gentamicin, sulfadimidin, trimethoprim and dexamethasone (Coliprajet®, Hipra) for 3 consecutive days.
In the present study, all bacterins evoked a serological response in the vaccinated animals. However, after challenge with a highly virulent M. hyopneumoniae strain, a clear protection against macroscopic lung lesions was not demonstrated in these animals. This confirms a lack of correlation between serum antibodies and protection [20–22]. Studies aiming to elucidate immune mechanisms playing a role in protection against infection with this very fastidious micro-organism are urgently needed.
It is remarkable that vaccination with a bacterin based on the homologous M. hyopneumoniae strain did not result in an increased protection in comparison with bacterins containing other strains, including the J-strain which has been shown to be antigenically quite different from the challenge strain [7, 11]. In a previous study, it was demonstrated that the effect of vaccination with a whole cell bacterin on the course of an experimental M. hyopneumoniae infection may vary, depending on the strain used for challenge . Further studies are required to elucidate the importance of the M. hyopneumoniae strain included in the vaccine for induction of protection. Such studies may include vaccines with different amounts of antigen and different adjuvants.
The challenge infection was successful because in all infected pigs, lung lesions were induced and M. hyopneumoniae was demonstrated by nPCR testing in BAL fluid at the end of the study. The values for RDS and lung lesions in the positive control group E (non-vaccinated, infected) were similar to those found in previous experimental studies using the same challenge strain [4, 5, 16]. Based on nPCR testing, serology and histopathology, the negative control group F remained negative for M. hyopneumoniae throughout the study. This confirms that the pigs used in this study were free of M. hyopneumoniae. It is not clear which pathogen may have caused the very mild pneumonia lesions in two pigs of group F, and neither what may be the reason for the positive IF testing found in one of these pigs (only one of the three sampled lung lobes).
Vaccination with commercial M. hyopneumoniae bacterins generally provides significant improvement of clinical symptoms and lung lesions [1, 2]. In the present study, clinical symptoms (average 0.38 in vaccinated groups versus 0.45 in group E) and histopathological lesions (average 3.20 in vaccinated groups versus 3.45 in group E) were lower in the vaccinated groups, but the difference was only moderate, and smaller than in previous experimental infection studies [5, 16]. In addition, the macroscopic lung lesions in the vaccinated groups (4.34) were on average similar to those in the positive control group (4.03). The reasons for this are not clear. The number of M. hyopneumoniae organisms was kept similar in the different bacterins to avoid that concentration of M. hyopneumoniae cells in the different bacterins would have biased the results. It is possible that the concentration in the bacterins of the present study (7.7 log10 CCU/ml, before inactivation) was lower than in commercial bacterins, and that this can (partially) explain the poor or moderate efficacy. The antigen concentration in commercial bacterins is expressed in different units and therefore not directly comparable with the concentration of the present bacterins.
The bacterins in the present study were not able to prevent colonization nor to eliminate M. hyopeumoniae from the lung tissue, as the percentage of pigs with positive nPCR in nasal swabs and BAL fluid were the same for groups A-E. Previous studies had shown that also commercial vaccines cannot prevent colonization with M. hyopneumoniae and are not able to significantly reduce the transmission of the organism. All bacterins did induce serum antibodies rather quickly, as in all vaccinated groups except for group A, serum antibodies were already detected at D28 i.e. 3 weeks after the first vaccination. At the time of challenge (D56), all vaccinated pigs had detectable serum antibodies.
Performance parameters are generally included in experimental studies with M. hyopneumoniae [5, 8] mainly because it is not that cumbersome to weigh a small number of pigs and to measure feed consumption. In general, no significant results are obtained because of the high standard deviation for these parameters and the rather small number of pigs included in experimental studies. This was also the case in the present study. The rather high number of pigs that died during the study, mainly due to E. coli infection before challenge, may also have influenced the performance of the pigs. Although performance parameters are very important from a financial point of view, these parameters are better investigated under practical circumstances rather than under experimental conditions.
In conclusion, no significant differences in protective efficacy were observed between three newly developed bacterins based on M. hyopneumoniae field strains and a bacterin based on the J-strain. Further research is necessary to better characterize the antigens involved in protection and to elucidate the protective immunity responses following M. hyopneumoniae vaccination and/or infection.
The authors thank Hanne Vereecke for the help throughout the clinical trial and for providing assistance in the laboratory. The study was financed by the faculty of veterinary medicine, Ghent University.
- Thacker EL: Mycoplasmal diseases. Diseases of Swine. Edited by: Leman, A.D., Straw, B.E., D'Allaire, S., Mengeling, W.L., and Taylor, D.J. 9th edition. The Iowa State University Press, Ames, IA, 2006, 701-717.Google Scholar
- Maes D, Segales J, Meyns T, Sibila M, Pieters M, Haesebrouck F: Control of Mycoplasma hyopneumoniae infections in pigs. Vet Microbiol. 2008, 126 (4): 297-309. 10.1016/j.vetmic.2007.09.008.View ArticlePubMedGoogle Scholar
- Moreau IA, Miller GY, Bahnson PB: Effects of Mycoplasma hyopneumoniae vaccine on pigs naturally infected with M. hyopneumoniae and porcine reproductive and respiratory syndrome virus. Vaccine. 2004, 22: 2328-2333. 10.1016/j.vaccine.2003.10.041.View ArticlePubMedGoogle Scholar
- Vicca J, Maes D, Jonker L, de Kruif A, Haesebrouck F: The efficacy of tylosin premix for the treatment and control of Mycoplasma hyopneumoniae infections. Vet Rec. 2005, 156: 606-610.View ArticlePubMedGoogle Scholar
- Villarreal I, Maes D, Vranckx K, Calus D, Pasmans F, Haesebrouck F: Effect of vaccination of pigs against experimental infection with high and low virulence Mycoplasma hyopneumoniae strains. Vaccine. 2011, 29: 1731-1735. 10.1016/j.vaccine.2011.01.002.View ArticlePubMedGoogle Scholar
- Stakenborg T, Vicca J, Butaye P, Maes D, Peeters J, de Kruif A, Haesebrouck F: The diversity of Mycoplasma hyopneumoniae within and between herds using Pulsed Field Gel Electrophoresis. Vet Microbiol. 2005, 109: 29-36. 10.1016/j.vetmic.2005.05.005.View ArticlePubMedGoogle Scholar
- Calus D, Baele M, Meyns T, de Kruif A, Butaye P, Decostere A, Haesebrouck F, Maes D: Protein variability among Mycoplasma hyopneumoniae isolates. Vet Microbiol. 2007, 120: 284-91. 10.1016/j.vetmic.2006.10.040.View ArticlePubMedGoogle Scholar
- Vicca J, Stakenborg T, Maes D, Butaye P, Peeters J, de Kruif A, Haesebrouck F: Evaluation of virulence of Mycoplasma hyopneumoniae field isolates. Vet Microbiol. 2003, 97: 177-190. 10.1016/j.vetmic.2003.08.008.View ArticlePubMedGoogle Scholar
- Meyns T, Maes D, Dewulf J, Vicca J, Haesebrouck F, de Kruif A: Quantification of the spread of Mycoplasma hyopneumoniae in nursery pigs using transmission experiments. Prev Vet Med. 2004, 66: 265-275. 10.1016/j.prevetmed.2004.10.001.View ArticlePubMedGoogle Scholar
- Vranckx K, Maes D, Calus D, Villarreal I, Pasmans F, Haesebrouck F: Diversity and persistence of Mycoplasma hyopneumoniae strains differs between herds as revealed by multiple locus variable number of tandem repeats analysis. J Clin Microbiol. 2011, 49: 2020-2023. 10.1128/JCM.00125-11.PubMed CentralView ArticlePubMedGoogle Scholar
- Stakenborg T, Vicca J, Maes D, Peeters J, de Kruif A, Haesebrouck F, Butaye P: Comparison of molecular techniques for the typing of Mycoplasma hyopneumoniae isolates. J Microbiol Methods. 2006, 66: 263-275. 10.1016/j.mimet.2005.12.002.View ArticlePubMedGoogle Scholar
- Friis NF: Some recommendations concerning primary isolation of Mycoplasma suipneumoniae and Mycoplasma flocculare a survey. Nord Vet Med. 1975, 27: 337-339.PubMedGoogle Scholar
- Halbur PG, Paul PS, Meng XJ, Lum MA, Andrews JJ, Rathje JA: Comparative pathogenicity of nine US porcine reproductive and respiratory syndrome virus (PRRSV) isolates in a five-week-old cesarean-derived, colostrum-deprived pig model. J Vet Diagn Invest. 1996, 8: 11-20. 10.1177/104063879600800103.View ArticlePubMedGoogle Scholar
- Hannan PC, Bhogal BS, Fish JP: Tylosin tartrate and tiamutilin effects on experimental piglet pneumonia induced with pneumonic pig lung homogenate containing mycoplasmas, bacteria and viruses. Res Vet Sci. 1982, 33: 76-88.PubMedGoogle Scholar
- Morris C, Gardner I, Hietala S, Carpenter T: Enzootic pneumonia: comparison of cough and lung lesions as predictors of weight gain in swine. Can J Vet Res. 1995, 59: 197-204.PubMed CentralPubMedGoogle Scholar
- Villarreal I, Maes D, Meyns T, Gebruers F, Calus D, Pasmans F, Haesebrouck F: Infection with a low virulent Mycoplasma hyopneumoniae isolate does not protect piglets against subsequent infection with a highly virulent M. hyopneumoniae isolate. Vaccine. 2009, 27: 1875-1879. 10.1016/j.vaccine.2008.12.005.View ArticlePubMedGoogle Scholar
- Kobisch M, Pillon J, Vannier P, Magueur S, Morvan P: Pneumonie enzootique à Mycoplasma suipneumoniae chez le porc: diagnostic rapide et recherché d'anticorps. Recl Med Vet. 1978, 154: 847-852.Google Scholar
- Stark KD, Nicolet J, Frey J: Detection of Mycoplasma hyopneumoniae by air sampling with nested PCR assay. Appl Environm Microbiol. 1998, 25: 327-330.Google Scholar
- Clinical veterinary microbiology. Edited by: Quinn P, Carter M, Markey B, Carter G. Edinburgh: Mosby; 1994:254-259.Google Scholar
- Djordjevic S, Eamens G, Romalis L, Nicholls P, Taylor V, Chin J: Serum and mucosal antibody responses and protection in pigs vaccinated against Mycoplasma hyopneumoniae with vaccines containing a denatured membrane antigen pool and adjuvant. Aust Vet J. 1997, 75: 504-511. 10.1111/j.1751-0813.1997.tb14383.x.View ArticlePubMedGoogle Scholar
- Thacker E, Thacker B, Boettcher T, Jayappa H: Comparison of antibody production, lymphocyte stimulation, and protection induced by four commercial Mycoplasma hyopneumoniae bacterins. J Swine Hlth Prod. 1998, 6: 107-112.Google Scholar
- Thacker E, Thacker B, Kuhn M, Hawkins P, Waters W: Evaluation of local and systemic immune responses induced by intramuscular injection of a Mycoplasma hyopneumoniae bacterin to pigs. Am J Vet Res. 2000, 61: 1384-1389. 10.2460/ajvr.2000.61.1384.View ArticlePubMedGoogle Scholar
This article is published under license to BioMed Central Ltd. This is an Open Access article distributed under the terms of the Creative Commons Attribution License (http://creativecommons.org/licenses/by/2.0), which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.